INTERNAL CONTROL MODULE MEMORY ERROR
DTC error 65535 (Internal Control Module Memory Error) suggests a problem was caused within the said module. However, Electronic Control Modules are generally fairly robust and are designed with a MTBF of 1 million hours. My experience with electronic repairs over the past 30 years does not confirm this since I have had tons of electronic components failing during this time that was'nt expected to fail for at least another 10 years. Be that as it may, an Internal Control Module Memory Error may not even be caused by the module, so it should be the last component to suspect and replace because they are normally not cheap. Firstly check the battery Supply Voltage and verify that it is constantly about 12V or higher. Also make sure that the alternator is charging, since a faulty alternator can lead to a slowly discharging battery not able to supply the minimum voltage required by the module that is flagging the 65535. Next check to wiring harness to and from the "faulty" Control Module. Make certain that the module has a ground connection (earth). If VCDS displays an unexpected result or displays that the controller refused the command, it is most likely due to the wiring. Under intermittent wiring conditions it is generally difficult ifnot possible to clear a 65535 (00-10) or (35-00) or (35-10) or (37-10). Wiring harness and its connectors are prone to corrosion due to condensation especially in cold weather. If needs be, unplug the connector and clean them and if possible check the physical contact with an ohm meter (but disconnect the battery first). Any Internal Control Module Memory Error associated with the Power steering and ABS are critical and should be attended to immediately. Internal Control Module Memory Error associated with Airbags should be treated with caution since interrogation of the airbag with a scan tool could inadvertently trigger the airbag or turn on the airbag light which can only be switched off by replacing the airbag module. As can be seen below, virtually every electronic module can be a victim of 65535 - Internal Control Module Memory Error and as far as I am concerned, it most unlikely electronic design and quality control will permit such modules to be installed in production units. The lateral acceleration sensor tend to cause an 65535 airbag error, the vacuum hose inside the ECU taking pressure to the barometric sensor tends to cause a 65535 error in Jetta's, barometric sensor itself tends to cause 65535 in Skodas. As a last resort try replacing the module concerned.
Address 01: Engine
Chassis Type: 17 - VW Golf Citi
Part No: 6KS 906 258 k
Component: 1.4 MP9.0 26ZA0003
Shop #: 2227355880
65535 - Internal Control Module Memory Error
Address 02: Auto Trans
Chassis Type: 9M - VW Jetta IV
Control Module Part Number: 01M 927 733 KT
Component: AG4 Getriebe 01M 4891
Software Coding: 00000
Work Shop Code: WSC 00000
65535 - Internal Control Module Memory Error
Address 03: ABS Brakes
Chassis Type: 6Y - Skoda Fabia I
Part No: 6Q0 907 379 D
Component: ABS/ASR 5.7 FRONT V00
Coding: 00124
Shop #: WSC 13765
65535 - Internal Control Module Memory Error
Address 03: ABS Brakes
Chassis Type: 1J - VW G/J/B Mk4
Part No: 1J0 907 379 AB
Component: ESP 20 CAN V005
Coding: 00214
Shop #: WSC 31414
65535 - Internal Control Module Memory Error
Address 03: ABS Brakes
Part No: 1C0 907 379
Component: ESP 20 CAN V005
Coding: 18945
Shop #: WSC 01317
65535 - Internal Control Module Memory Error
Address 03: ABS Brakes
Chassis Type: 6Y - Skoda Fabia
Controller: 6Q0 907 379 G
Component: ABS 5.7 FRONT V20
Coding: 00044
Shop #: WSC 13765
65535 - Internal Control Module Memory Error
Address 08:
Chassis Type: 6Y - Skoda Fabia
Controller: 6Y0 820 045
Component: Klimaanlage X0740
65535 - Internal Control Module Memory Error
Address 08:
Chassis Type: 6Y - Skoda Fabia
Controller: 5J0 820 045
Component: Klimaanlage X0850
65535 - Internal Control Module Memory Error
Address 08: Auto HVAC
Chassis Type: 6L - Seat Ibiza/Cordoba
Part No: 6L0 820 045 C
Component: Klimaanlage X00.8
65535 - Internal Control Module Memory Error
Address 08: Auto HVAC
Part No: 5J0 820 045
Chassis Type: Skoda Fabia 2
Component: Klimaanlage X0850
65535 - Internal Control Module Memory Error
Address 15: Airbags
Chassis Type: 9N - VW Polo
Part No: 1C0 909 605 K
Component: 18 AIRBAG VW51 0P 0010
Coding: 12600
Shop #: WSC 00788
65535 - Internal Control Module Memory Error
Address 15: Airbags
Chassis Type: 9N - VW Polo
Part No: 6Q0 909 601 F
Component: 05 AIRBAG VW5 0010
Coding: 12341
Shop #: WSC 31414
65535 - Internal Control Module Memory Error
Address 15: Airbags
Chassis Type: 6L - Seat Ibiza/Cordoba
Part No: 6Q0 909 601 F
Component: 01 AIRBAG VW5 0010
Coding: 12337
Shop #: WSC 06441
65535 - Internal Control Module Memory Error
Address 17: Instruments
Chassis Type: 8E - Audi A4 B6/B7
Part No: 8E0 920 900 HX
Component: KOMBI+WEGFAHRS. RB4 D27
Coding: 00142
Shop #: WSC 19411
65535 - Internal Control Module Memory Error
Address 37: Navigation
Part No: 3B0 919 887 D
Component: Navigation BNO 0201
65535 - Internal Control Module Memory Error
Address 45: Inter. Monitor
Chassis Type: 6N - VW Polo
Part No: 6N0 951 171
Component: Innenraumueberw. 0002
65535 - Internal Control Module Memory Error
Address 56: Radio
Part No: 1C0 035 157 C
Component: Radio DE2 0004
Coding: 00401
Shop #: WSC 00066
65535 - Internal Control Module Memory Error
Address 56: Radio
Part No: 1J0 035 180 B
Component: Radio DE2 0004
Coding: 01031
65535 - Internal Control Module Memory Error
